Synthesis and Characterization of a Novel Class of Zwitterionic Fluorocarbon Surfactants Based on Perfluorobutyl

Abstract Perfluorooctane sulfonate (PFOS) and its derivatives had been banned due to their potential environmental hazards, although they possessed excellent surface activity. An effective method to solve this problem was to shorten the fluorocarbon chain of these surfactants from C ° H 17 to C 4 F 9 . As previous studies had shown, zwitterionic surfactants possess higher surface activity but have lower toxicity compared to other types of surfactants. In view of this, a class of novel zwitterionic fluorocarbon surfactants (n-CFNA-Br) with perfluorobutyl moiety was synthesized in this work. Their structures were characterized by FTIR, 1 H NMR, 13 C NMR, 19 F NMR and MS. The results showed that all synthesized n-CFNA-Br had almost the same minimum surface tension, but their critical micelle concentration (CMC) decreased with increasing length of hydrophobic carbon chain. In pure water, the surface tension at the CMC (γ CMC ) of the four n-CFNA-Br were about 20 mN/m, and the CMC values were 7.73 mmol/L for 1-CFNA-Br, 4.70 mmol/L for 2-CFNA-Br, 4.13 mmol/L for 3-CFNA-Br, and 3.36 mmol/L for 4-CFNA-Br, indicating high efficiency and effectiveness. In 0.1 mol/L NaCl, the CMC values reduced to less than half of the CMC values measured in the pure aqueous surfactant solution, while the surface tensions γ CMC remained almost unchanged, indicating good salinity tolerance of the synthesized surfactants. The acidic surfactant solutions exhibited similar CMC values to the saline solutions, but the surface tension γ CMC increased slightly to 25 mN/m. However, further investigation showed that the n-CFNA-Br surfactants exhibited poor surface activity in alkaline solution (0.1 mol/L NaOH). In the pH range of 6.6 to 10.4, white precipitates appeared in the surfactant solutions after some time, indicating that the n-CFNA-Br are not suitable for use in alkaline systems with pH greater than 6.6.